|
Ice from Pump
| |
Note: These articles
has been studied by our experts and we have found it as a viable technology
for eco sustainable villages modules however these old technologies has been
improved now.
Ice-Quick
|
The Ice-Quick is a small device to demonstrate the adsorption
technology with the sorption pair water/zeolite. It consists of a zeolite
filled cartridge, connected via an adaptor to a plastic cup, which
contains some water, and which is evacuated by means of a hand-vacuum
pump.
|
After approx. 10…20 strokes with the hand-vacuum pump the inside pressure
is reduced below the vapour pressure of the water at ambient temperature, and
the water start to boil. Air gases go out of the water and starts to bubble on
the bottom of the glass. (The more air is removed out of the system, the
better the adsorption of water vapour. The vapour above the water surface is
adsorbed in the cristalline structure of the zeolite. As a result, the
remaining liquid water cools down.) After a few more strokes the water calms
down and finally begins to freeze. After some time the water is completely
frozen: 50 g of water at a temperature of 10 °C can be cooled down and frozen
within 30 sec with 500 g of zeolite. The average specific cooling power
results to 390 W/kgZeo.
This process can be repeated 8…10 times with arbitrary intervals until the
zeolite is saturated. The zeolite has always to be cooled down to the ambient
in between processes for the adsorption to function properly. For desorption
(regeneration) the zeolite has to be heated up to 250 °C for a short time.
When the zeolite is cooled down again to 20 °C it is ready for further ice
production.
Advantages of the Ice-Quick and bottle cooler
 | An immediate cooling process can be started |
 | The cooling process (without any capacity loss) can be interrupted at any
time |
 | Ice production is possible without any electric power |
Ice-making instructions
- Take a plastic cup and fill not more than 1 cm
(0,4 inch) of water into it. Place the system on a flat surface.
- Check that the PVC-hose is fixed to both the
adaptor and the pump. The cartridge is firmly tightened to the adaptor.
- Connect the cartridge and the adaptor to the
plastic cup.
- Operate the vacuum-pump continuously, but not too
fast. Push the piston-rod to the very end. Overcome the resistance of the
final air-cushion.
- Check the tightness of the unit after approx.
2 strokes by lifting the cartridge. Because of the produced vacuum, the cup
with the water is firmly tightened to the adaptor
- After approx. 10…20 strokes the inside pressure is
reduced below the vapour pressure of the water at the ambient temperature,
and the water starts to boil. Air gases go out of the water and start to
bubble on the bottom of the glass.(The more air is removed out of the
system, the stronger becomes the adsorption of water vapour. The vapour
above the water surface is adsorbed in the cristalline structure of the
zeolite. As a result the remaining liquid water cools down.)
- After a few more strokes the water calms down and
begins to freeze. Wave the water-cup and the cartridge severaltimes so that
water can reach the surface, and continue the operation of the vacuum-pump.(At
the same time the zeolite gives out the heat of adsorption. After 1…2 min
the heat can be felt on the outside of the cartridge. With a heat exchanger
it is possible to use little heat in existing aggregates, for example, for
heating water or on an air stream.)
- The adaptor has a small flap. Lift it briefly in
order to let air into the system, so that the cartridge and the adptor can
be removed from the cup.
This process can be repeated 8…10 times with
arbitrary intervals until the zeolite is saturated. The zeolite has always to
be cooled down to the ambient in between processes for the adsorption to
function properly. For the regeneration the zeolite granulate needs to be
activated by heating it at 250 °C in the oven
Regeneration
- Separate cartridge and adaptor from each other.
- Unscrew the nut from the central-pipe which is
inside the cartridge. Take out the lattice
- Spread out the zeolite granulate on a baling tray
and put it into an oven for 2 hours at a temperature of 250 °C.
Alternatively, put the cartridge with the zeolite directly in the oven for 3
hours.
- Cover (for example aluminium foil) the granulate
after the regeneration, and cool it down so that no humidity is adsorbed by
the zeolite.
- Refill the cartridge in closing the central-pipe,
refix the lattice and put the nut again on the central-pipe.
- Please make sure that there is no zeolite
granulate in the inside of the central-pipe by turning the zeolite cartridge
up-side-down
The Ice-Quick is now ready to start
again.
Storage
To store the Ice-Quick the zeolite cartridge has to be deposited in a dry
ambient. Place the empty and dry plastic cup directly on the adaptor.
In this way the renewed energy in the zeolite during the regeneration
process can be stored without losses for as long as required.

Crosley IcyBall
| Crosley bought the rights to the
Icyball refrigeration idea, and brought it to market. Powel Crosley had a
gift for recognizing great ideas and gift for marketing. Crosley built
thousands of Icyballs in at least two factories, one in the United States
and one in Canada. Icyballs have been spotted throughout North America and
as far away as Africa. The Canadian made Icyballs carry a tag indicating
that they are Deforest Crosley Icyball, those made in the USA are labeled
Crosley Icyball. The Icyball is an intermittent heat absorption type of
refrigerator. A water/ammonia mixture is used as the refrigerant . Water
and ammonia combine easily. So, they combine in the hot ball at room
temperature.
When the hot ball is heated, for about 90 minutes, the ammonia
evaporates first because it has a lower boiling point than water. The
other cylinder is in water to help condense the ammonia in the cold ball.
When the balls are fully charged, the cold ball is placed in the insulated
box, as the ammonia evaporates to recombine with the water in the hot ball
it removes heat, cooling the inside of the refrigerator for 24+ hours. A
hole in the cold ball was for a special ice cube tray.
If the above isn't completely correct, it's because I really don't know
anything about refrigeration, This page is our complete file on the
Icyball if you have additional ads or information please let me know. |

|
 |
Icyball at the Smithsonian
The exhibit at left was found while wandering through the Smithsonian
Institution's National Museum of American History in Washington DC.
The display tells how Ferdinand Carre discovered the absorption
refrigeration cycle in the mid 1800s. In around 1858 he marketed the black
device above the Icyball for use as a cooling device in homes.
The Carre absorption cycle was an outgrowth of an observation by
Michael Faraday in 1823 of the cooling properties of ammonia and silver
chloride enclosed in a bent glass tube. The ammonia absorption system was
similar to the process Edmund Carre, Ferdinand's brother discovered that
used strong acids under a vacuum but was much more practical. |
|
Deforest Crosley IcyBall SN-775
Built in Toronto
This Icyball was found in the Toronto area and is in very good
condition. It was successfully put through a heat charge cycle on
November 28th 1998. It produced a temperature of 18 degrees F, in the
ice cube tray hole with no insulated box to help the process. Not bad
for a 70+ year old refrigerator.
|
 |
Warning
Don't try this with your Icyball unless you are very careful,
outdoors, and reasonably sure of the condition. Read the Operation
Manual. |
|
 |
If
you had X-Ray Vision
This is what you would see looking at a charged Icyball. The left
ball is the cold ball and has liquid ammonia in it after the heat
cycle, with gas evaporating off the surface, on its way to reunite
with water in the hot ball on the right. |
|
|
|

|
|
|
Icyball Ads
A few ads have shown up so far, both full page and smaller. The "Farm
Mechanic" magazine was one of Crosley's favorite for advertising with 3
full page ads that I have heard about, I have only found one and have a
scan of a second. The one to the Left was the outside back cover of the
September 1928 issue. Country Gentlemen is another good source I have
heard of two, only managed to get copies of one so far. |
|
|
Crosley
Broadcaster Feb 15, 1929
These two pieces are from the Crosley newspaper they sent to dealers.
The cover to the left shows several interesting Icyball applications.
Lower left is a large 2 Icyball cooler and the bottom picture shows an
Icyball water cooler.
|
 |
|
Scientific American September 1929

|
Crosley
Broadcaster April 15th 1929

"The Shuler Supply company of New Orleans, La., use a large chest on an
over-size trunk rack to transport the Crosley Icyball Refrigerator to any
part of the city for demonstrations. The large sides of the chest are used
as advertising space to bring the Crosley Icyball Refrigerator to the
public eye when Shuler salesmen speed from one demonstration to another" |
|
Flea Market Sightings
| Seen at a Steam Tractor show in Southern Indiana |
 |
|

Spotted at the 1998 Kent CT Tractor & Engine Show. Notice that the cold
ball is different from the diagrams and Icyball 775 show above. Not sure
when they changed or why. Any ideas? Is it the difference between Canadian
and US built units? A reader with a sharper eye than mine wrote to point
out that this is a left handed Icyball, intended for hanging off the left
side of a cabinet instead of the more common right.
The Sign says "What is This?", since the Crosley Club's Yankee Region
was at the show, he got tired of being told. |
|
Home Built
Some people make there own Icyball. Larry Hall built this one and it
worked great.
For pictures of some home made Icyballs and Larry Hall's plans to build
your own click on the picture to the right. |
  |
|
|
Instructions for Crosley Icyball
Refrigerator
(PatentPending)
A Crosley Icyball will keep the interior of the cabinet colder than ice
will keep it.
Its dry, cold air preserves food better and keeps vegetables crisp. |
|
|
|
PROCEDURE
A - Remove cap from steam
dome and fill dome with water (preferably soft water). Replace cap
tightly. (See "Steam Dome.")
B - Remove ice tray from
freezing tube in "cold ball" and place unit in draining position&emdash;(Figure
1.)
C - Place tub on stand in
convenient location for heating operation, preferably in basement and fill
to the top bead (Figure 2) with cool soft water before
submerging cold ball.
D - Hang wire bracket on
rim of tub, facing stove (Figure 2.)
E - When cold ball is
drained empty (see "Draining") submerge the "cold ball" in the tub of
water, hooking the catch over the rim of the tub and resting the "hot
bail" against the wire bracket&emdash;(Figure 2).
F - Place the stove
directly under the "hot bail" leaving a apace of about ~ of an inch
between the bottom of the ball and the top of the stove (for oil stove see
"Stoves").
G - For gas or gasoline,
light the stove and adjust the flame so that its tips just touch the
circular space inside the lower ends of the fins on the bottom of the "hot
ball."
H - Sizzle Test. Heat the
unit slowly in this way, so that at the end of l 1/2 hours, and not
before, a drop of water placed on top of the connecting tube under the
handle (Figure 2) will sizzle, turn white and boil. The whistle is an
additional signal which operates towards the end of the heating to remind
you to make this sizzle test. (See "Heating.")
I - Turn out the flame and
remove the unit from the heating position. Place the hot ball in the tub
of water so that the steam dome and whistle are completely submerged&emdash;thus
enabling the steam dome to refill&emdash; and hook the catch over the rim
of tub with the large vertical tube resting against the wire bracket.
(Figure 3.)
J - Leave the unit in this
position until the bend of the tube, above the cold ball, becomes cool or
slightly below room temperature. This should require from five to ten
minutes.
K - If the Icyball
Stabilizer is used, remove cap from it, pour in three pints of glycerin,
or the same amount of any other odorless anti-freeze radiator solution,
then fill with cool water and replace cap.
L - Place Stabilizer in
bottom of cabinet so cold ball will fit in it when unit is in operating
position (Figure 5.)
M - Place the unit In the
Cabinet with the hot bail outside and the cold ball resting in the bowl of
the Stabilizer. The end of the vertical pipe will fit in the stirrup on
the inside of the Cabinet.
N - Fill the ice tray with
water or liquid to be frozen and slide the tray into the freezing tube as
far as it will go.
O - If the Cabinet is warm
or the stabilizer has just been filled when the unit is put in, the unit
should be heated three times at twelve hour intervals to obtain best
results from the Crosley Icyball and Stabilizer. |
 |
| |
|
|
|
|
CARE AND OPERATION
Steam Dome - The steam dome must
be filled only when the unit is first put in operation or after cleaning. At
other times it fills itself when the hot ball is placed in the tub of water,
after heating. This operation will completely fill the dome. When the unit is
placed in the draining position before the next heating, the excess water will
drip out of the whistle until the water reaches the level for proper operation.
Soft water should be used where available so that the continual boiling will
not form scale, which has a tendency to stop up the whistle and vent. The steam
dome should be flushed out occasionally, using sal soda to dissolve and remove
scale.
Draining - The unit must be
placed in the draining position (Figure 1) before each heating. The actual
draining should not require more than 3 to 5 minutes. However, if the unit is
new or has not been operated for several weeks or if the previous heating has
been too rapid, the draining may require more time. This can be hastened and
complete draining assured by slowly pouring a tea-cup full of boiling water on
top of the cold ball while in the draining position. A cloth saturated with
boiling water will also accomplish the same result.
To test for complete draining, place your hand on the bottom of the cold ball
- (which will feel warm from the hot water) - and tip unit slowly from draining
position to its normal position on the floor. (Note dotted line Figure 1.) If
the ball remains warm in this operation, the unit is completely drained and
ready for heating. If It chills repeat above operation.
Water - The water may be left in
the tub and used for subsequent heatings, although the cooler the water the
better the results will be. In very hot weather, or where cool water is not
available, it is often worth while to change some of the water in the tub 20 to
25 minutes before the heating is complete. Where convenient, best results will
be obtained by running a small stream of cool water into the tub while the hot
ball is being heated.
However, no part of the cold ball should ever be allowed to stand above
the surface of the water when heating.
Soft water should be used where available in the tub since the steam dome
takes up some of this water when the hot ball is placed in it. Rain water is
best, although hard water may be softened by stirring a cupful of sal soda into
the tub of water.
Whistle - The whistle is
adjusted at the factory and will blow towards the end of the heating to remind
you to make the sizzle test.
If the whistle becomes dirty or ceases to operate at the proper time, it may
be cleaned with a fine needle and some sal-soda water. Readjustment is made by
means of the set screw and jock nut on the vent so that the whistle will begin
to blow when the unit has been heated about 134 hours and just before it is hot
enough for the sizzle test. Care must be taken not to run the set screw in too
far or it will cause the water to boil out of the whistle with a possibility of
putting out the fire. Dirt, scale or lime collected in the vent will also cause
this difficulty.
Heating - The rate of heating is
very important and may require a little practice but after a few trials you will
be able to regulate the flame so that the unit will not be heated in less
than 1 1/2 hours.
If it requires more than 1 1/2 hours heating, to obtain the sizzle test the
efficiency of the unit will not be affected. A low flame will often take 2 hours
or more to show the test; never have the flame hot enough to give the sizzle
test in less than 1 1/2 hours, or you will not obtain best results.
Stoves- The position of the
stove to the unit and size of flame for use with gas stoves have been described
in the main instructions.
The Perfection kerosene stove has been designed especially for the Icyball
and is recommended.
Any type of stove or heat can be used if the heat is regulated so that the
unit will not show the sizzle test in less than 1 1/2 hours.
Stabilizer - The stabilizer need
never be moved after it is installed except for cleaning in and around it. After
the liquid in the Stabilizer has once become chilled, it will hold the box cold
and increase the hours of refrigeration of the Icyball.
Ice Tray - The ice tray may be
used to freeze ice cubes or frozen desserts, but the best results will be
obtained if cool water is used in the tray or if the dessert to be frozen is
allowed to become cool before placing in the tray.
 | Be sure that none of the liquid is spilled when the tray is being inserted
into the ball, or the tray may become frozen fast to the ball making it
difficult to remove. |
 | The tray may be removed by lifting up on the tray handle until it loosens
and drawing it out. |
 | Frozen cubes may be removed from the tray by holding the tray upside down
and allowing water to run over it. |
General Advice - The unit should
be reheated whenever necessary; more often in hot weather than in cool weather.
Best results will be obtained by heating the unit in the morning, when the
water in the tub is cooler than at any other time of the day. When it is heated
at this time the unit will be most efficient during the hottest part of the day.
It is often convenient to heat the unit in the cellar where the water
standing in the tub will remain cool.
While the unit is cooling the cabinet, the hot ball will he warm, because the
heat from the cabinet and freezing ice is being transferred to the hot ball and
thence to the air.
During cold weather it is possible to control the temperature inside the
cabinet by covering the hot ball, with a muslin or paper bag.
If the unit is not used during the winter months drain the steam dome
thoroughly to prevent freezing. The unit then will not be harmed unless the
temperature is lower than 40 degrees F. below zero.

Guarantee
The Crosley refrigerator is guaranteed by the manufacturer against defects in
material and workmanship for a period of one year, and such part or parts as are
found in the manufacturers opinion to be defective, upon receipt at the factory.
transportation charges prepaid, not later than one year after purchase by the
consumer will be replaced with new and perfect parts.
The guarantee is expressly in lieu of any other guarantee, expressed or
implied, and of all other obligation or liabilities on our part. We neither
assume nor authorize any representative or any other person to assume for us any
other liability in connection with the sale of our refrigerator.
This guarantee shall not apply to any refrigerator which shall have been
tampered with so as in our judgment to affect its proper operation, or which has
been subject to misuse, negligence or accident.

ISAAC Solar Ice
Maker
The ISAAC
Solar Icemaker is an Intermittent Solar Ammonia-water Absorption Cycle. The
ISAAC uses a parabolic trough solar collector and a compact and efficient design
to produce ice with no fuel or electric input, and with no moving parts.
The ISAAC
Solar Icemaker operates in two modes. During the day, solar energy is used to
generate liquid ammonia refrigerant. During the night, the generator is cooled
by a thermosyphon and ice is formed in the evaporator compartment as ammonia is
reabsorbed to the generator.
The daily
ice production of the ISAAC is about 5 kg per square meter of collector, per
sunny day. The construction of the ISAAC Solar Icemaker involves only welding,
piping and sheet metal work, and there are no expensive materials. It is
estimated that, when produced in-country where wages are low and transportation
costs can be minimized, the 11 square meter
ISAAC can be produced for less than $7,000. When produced in-country, the
creation of urban employment is an additional advantage of ISAAC technology.
The
characteristics of the ISAAC which make it particularly well suited to provide
refrigeration to unelectrified rural communities are:
1.
It is solar thermally powered, avoiding expensive diesel fuel or
photovoltaics.
2.
Low cost construction requires only welding, piping and sheet metal work.
3.
Very low maintenance.
4.
The quantity of ice is sufficient to support small scale businesses while
maintaining sustainability in fragile environments, or provide low cost
household refrigeration.
The ISAAC
design was developed by Energy Concepts Company. Over forty systems have been
built and twenty installed in seven countries. The ISAAC is on display in
Annapolis, Maryland and at Sandia National Lab, Albuquerque, New Mexico. ISAAC
is now being distributed and commercialized by Solar Ice Co.
Providing
Jobs to Remote Communities - By Providing Ice
The ISAAC Solar Icemaker
makes enough ice at low cost to support many small scale businesses in rural
unelectrified areas. Enterprises using ISAAC will be environmentally sustainable
because no fuel is required. They will be economically sustainable because the
cost of producing the ice by the ISAAC is sufficiently less than the value of
the ice that it can easily be recovered by a micro-enterprise.
Ice is of
major economic importance. In rural communities of developing countries, there
is frequently a shortage of ice to support business activities. The result is
loss of revenue, jobs, and substantial food spoilage.
Three
important community needs for electricity are:
 |
lights
|
 |
communications and entertainment
|
 |
refrigeration. |
Lights,
communication and entertainment require modest amounts of electricity and are
affordable even at the high cost of
electricity from emergency generators, diesel mini-grids or photovoltaics.
When
refrigeration is needed also, the amount of electricity required from the power
system increases drastically. Thus it is usually omitted to keep costs down. An
ISAAC Solar Icemaker supplies refrigeration without the intermediary step of
electricity and at a much lower cost. Thus ISAAC Solar Icemakers, in combination
with mini-grids and/or photovoltaics, are a good method of supplying remote
community needs.
For
example, ISAAC can provide domestic refrigeration. An ISAAC produces six blocks
of ice each day, weighing ten kilograms each. If an icebox requires five
kilograms of ice per day to stay cool, then one ISAAC will be able to supply
domestic refrigeration to twelve households. The cost of a standard electric
refrigerator, plus the constant requirement of expensive electricity, would be
much higher.

|